Please wait.'

Page is loading'


Home  > Raw materials & technologies  > Technologies  > Superhydrophobic surfaces with silane-trea...

Thursday, 19 September 2019
pdf
Raw materials & technologies, Technologies

Superhydrophobic surfaces with silane-treated diatomaceous earth/resin systems

Monday, 1 August 2016

In a study, superhydrophobic coatings were prepared using fluorosilane-treated diatomaceous earth (DE) with either polyurethane or epoxy binders.

Researchers prepared superhydrophobic coatings using diatomaceous earth with polyurethane or epoxy binders. Source: Rainer Sturm/pixelio.de

Researchers prepared superhydrophobic coatings using diatomaceous earth with polyurethane or epoxy binders. Source: Rainer Sturm/pixelio.de

The surface wettability and morphology of the films were analysed using contact angle measurements and scanning electron microscopy (SEM), respectively. The water contact angles were studied as a function of the fluorocarbon fraction on DE and the particle loadings of treated DE in the coating.

Contact angles exceed 150° for coatings

The contact angles exceeded 150° for coatings with at least 0.02 fluorocarbon fraction (mass of fluorosilane/mass of particle) on the DE and with 0.2 particle loadings (mass of treated particles/mass of coating). The water contact angles of the surfaces were dependent on the nature of the binder below 0.2 particle loadings of the superhydrophobic DE particles, but were independent of the binder type after attaining superhydrophobicity.

Treatment with fluorosilanes restricts pores in DE

The results were consistent with the superhydrophobicity resulting from the migration of the superhydrophobic DE moving to and covering the surfaces completely. It was also shown that the treatment with fluorosilanes restricted the pores in DE and reduces the specific surface area of the material. However, these changes had effectively no effect on the superhydrophobicity of the coatings. The results of this work clearly identify some important considerations relative to producing superhydrophobic coatings from inexpensive diatomaceous earth. 

The study is published in: Journal of Applied Polymer Science 2016, 133, 44072.

top of page
Comments (0)
Add Comment

Post comment

You are not logged in

register